Five years on the road: Nova Scotia has many highway improvement projects planned

Carroll McCormick
June 14, 2018
By Carroll McCormick
June 14, 2018 - From fixing gravel roads to twinning more stretches of 100-series highways to rehabilitating the province’s third-longest bridge, Nova Scotia’s Department of Transportation and Infrastructure Renewal (TIR) has assembled an ambitious five-year highway improvement plan.
TIR is launching the Plan with a bang: The 2018-19 budget, at $285 million, and spread out over 180 projects, is the most generous since the $281-million budget of 2012-13, and is about $70 million more than the average annual budget for the past four years (The province has 23,000 kilometres of roads and highways). The Plan lists 14 major highway construction projects for 2018-19, with most of them on 100-series highways (they account for $115 million of the 2018-19 budget). While they include a handful of access improvements, eight are multi-year projects, such as more twinning work on Highways 101, 103 and 104, all three of which are scheduled to last until at least 2022.

The Plan notes three projects for which roundabouts will be built: on the 101 exit for Digby; Granite Drive in New Minas; and for the new, New Minas Connector, on the 101, for a total of four roundabouts.

In June 2017, TIR noted that it had 32 roundabouts, but this may not be correct, by standard arithmetic. In TIR lingo, revealed in a caption under a photo for the Trunk 7 Interchange outside Antigonish, two roundabouts may be referred to as “a roundabout.” Therefore, the number of roundabouts in the province could be many more than 32.

“In general, roundabouts are a safer alternative to traditional 90 degree intersections; however, different traffic conditions call for different solutions. Engineers study one intersection at a time and consider a variety of factors when determining whether a roundabout is the best solution for an intersection. These factors include improved safety, traffic conditions, geometry and infrastructure,” says Marla MacInnis, media relations advisor for the Province of Nova Scotia.

Of note, perhaps, for companies with concrete roadbuilding expertise, is the repaving of the 10.9-kilometre section of the 101 running eastward past Ellershouse, a rare concrete feature laid down in 2003, according to TIR. Does TIR do much concrete roadbuilding?

“TIR does some... concrete pavement becomes competitive with asphalt and more cost effective in areas with high traffic volumes and heavy trucks stopping and turning. Therefore, concrete is not as competitive in jurisdictions such as the Maritimes. Where concrete pavement has been used in Nova Scotia, there was a significant life cycle cost analysis premium placed on them in the tender to even the playing field with asphalt’s lower construction costs,” MacInnis says.

Of interest to others will be how TIR plans to handle the twinning of the one-kilometre long causeway that crosses the Avon River in Windsor – part of the twinning of the section of the 101 between Three Mile Plains and Falmouth. Bemoaned as an environmental disaster by some, and as a gift to the town’s waterfront by others, will it simply be widened with more fill, or changed with, perhaps, a bridge feature, to return it to being a tidal river, with its salmon run, that it once was?

ATIR lists 82 asphalt projects for 2018-19, valued at $101.5 million. “Approximately 10 companies will be involved in asphalt work this year,” MacInnis says.

They include a dozen 100-series repaving tasks, repaving “arterial/collectors,” and repaving local roads. Pavement strengthening, to allow for heavier loads, single-lift overlays and maintenance paving are other descriptors TIR uses to characterize the asphalt work to be done elsewhere.



TIR notes in the Plan that pavement preservation is an important goal: “Spending $1 on pavement preservation before a paved road is 15 years old can eliminate or delay having to spend $6 to $14 on rehabilitation or reconstruction when the pavement surface has failed.”

MacInnis adds, “Pavement preservation is either chip seal, micro seal or a thin lift of asphalt placed over an asphalt surface that was paved approximately five years earlier. Rehabilitation occurs when the asphalt surface has completely failed and it needs to be rebuilt. This may also include the replacement of drainage structures and improving the road drainage.”

Judging from the sorry state of many secondary paved roads, riddled with tire-destroying potholes and long stretches of failed subbase, there will be lots of rebuilding to keep contractors’ heavy machinery revving. One such obstacle course, between Berwick and Aylesford, in Kings County, is on this year’s hit list as a 6.3-kilometre project.

Nova Scotia has about 9,000 kilometres of gravel roads, and TIR has created a new funding category called the Gravel Road Program. With a budget of $20 million, it consists of 81 separate projects from Cape Breton to Yarmouth. All of them listed in the 2018-19 fiscal year; none are noted for the remaining four years of the Plan. These apparently do not include regular grader maintenance for gravel road.

The Plan states that the province has 4,100 bridges. Thirty-seven of them are slated for rehabilitation or replacement in the Plan, and TIR has allocated $29.1 million of the 2018-19 budget to get shaking on the first 10. Strung out from 2018 to 2022, the 37 bridges run from a small one in Hillaton, on Route 358 outside Canning, in Kings County, to four seasons of work on the Great Bras d’Or Crossing Bridge, also known as the Seal Island Bridge, in Cape Breton. The Plan refers to major bridge replacements, but provides little detail on just what each bridge project is about, describing each simply as “major bridge projects” or “other bridge projects.”

The Plan does note that three are multiple-year projects: the Lennox Passage Bridge, Bennery Brook Bridge (three years) and the Great Bras d’Or Crossing Bridge. Completed in 1961, and running between Sydney and Baddeck, this 747-m bridge consists of eight steel box truss spans. Between 2002 to 2004, the road deck was replaced with a precast concrete deck system, and steel trusses reinforced.

MacInnis describes work to be done on the bridge, at least as far as what is currently understood to be required goes: “This work involves a full structural analysis and from that report we will
determine what is required for rehab over the next few years. This could include sandblasting, repainting, etc. We won’t know until the analysis is complete later this year.”

In the next four fiscal years, no gravel road projects are listed, and the anticipated pace of work will slow. For example, just 23 asphalt projects are noted for 2019-20, 16 for 2020-21, 17 for 2021-22 and eight for 2022-23. However, the list is not final, as there are several “projects to be determined” notes.

Add comment


Security code
Refresh

Subscription Centre

 
New Subscription
 
Already a Subscriber
 
Customer Service
 
View Digital Magazine Renew

Most Popular

Latest Events

SC&RA Crane & Rigging Workshop
September 26-28, 2018
CTAA Annual Convention
November 11-14, 2018
SHCA Annual Fall Convention
November 15-16, 2018
Fort McMurray ASGA Lunch
November 29, 2018

We are using cookies to give you the best experience on our website. By continuing to use the site, you agree to the use of cookies. To find out more, read our Privacy Policy.